R1
10Installation
11Basement InstallationTo install a DVC 500 in a basement you will need additional DVC vent sections. These sections are made with a 316-grade stainl
12Installation
13Installation
14InstallationHarman Direct Vent Coal Flue Pipe Venting System 1" Clearance to CombustiblesExterior Termination for wall thickness up to
15ESP CONTROLFeed AdjusterSets the maximum feed rate, 1 to 5TestRuns all motors at full speed for two minutes to check operation. After two minutes th
16ESP ControlHopper Lid LatchAsh Door Latch HandleGlass Door Latch HandleSide Panel Latch
17Testing Operation:Turn the Feed Adjuster to "Test" mode, (g. 13.) This will cause all motors to run 100% for 2 minutes. The ligh
18This setting will produce medium heat with the Dis-tribution Blower on "low".This setting will produce a room temperature of 70 de-grees w
19WARNINGOPENING THE VIEWING DOOR OR ASH DOOR WITHOUT TURNING THE FEED ADJUSTER TO THE "ASH OUT" POSITION MAY CAUSE COMBUSTION GASES AND
2This appliance is also approved for installation into a shop.LISTED SOLID FUEL BURNING ROOM HEATER - MODEL: “DVC 500”Serial Number:WHI- W/N 03625
20WEEKLY MAINTENANCEFINES TRAY COVEREmpty Fines Tray The small Fines Tray in the side of the stoker should be removed and emptiedTo remove the Fines T
21A 3-month cleaning will give you a base line as to how often your DVC500 needs to be cleaned. Cleaning intervals will differ in each installation be
22The End Of Season Shut Down List.1. Allow the stove to run out of coal in order to extin-guish the re. This saves having to remove the coal from th
23 MotorsFuelThe DVC500 is designed to burn Anthracite Rice Coal, which is approximately 3/8" long and wide by 3/16 thick. Anthracite
24The DVC500 grate system is composed of four pieces: the grate holder, (2)-63 hole grate inserts, and grate angle. The grate angle is bolted to th
25Maintenance ScheduleIt is recommended that End of Season Cleaning and the Annual Service are coordinated to happen at the same time for best results
26Control and Safety SensorsESPThe ESP (Exhaust Sensing Probe) is a temperature sensing probe located in the exhaust outlet. The ESP works with the Co
02/11
02/11IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number an
02/11IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number an
3INDEXWarnings 4 Introduction 5Assembly
30SpecicationsWeight 500 PoundsBTU Output Range 7000 to 75,000Heating Capacity 2200 Square FeetFuel Anthracite Ric
312 Blink Status Details:DVC 500-CFirebox Static Pressure Safety ProtocolThe DVC-500 operates with a negative pressure rebox as a safety featur
32Causes And/Or Reasons For (2-blink) Shutdown:The DVC-500 operates with a negative pressure rebox as a safety feature. Any loss of this negati
334021-645C 12-29-10 Page 1 of 2Hearth & Home Technologies Inc.LIMITED LIFETIME WARRANTYHearth & Home Technologies Inc., on behalf of its hea
344021-645C 12-29-10 Page 2 of 2WARRANTY CONDITIONS:• This warranty only covers HHT appliances that are purchased through an HHT authorized dealer o
35
Proudly Printed On 100% Recycled Paper
4Always empty the hopper when not burning for more than a week. When left standing for long periods with wet coal, the pusher block will rust and cor
5 INTRODUCTIONThis remarkable design by Harman features the Verti-ow Direct Vent Stoker System. This unique, high efciency unit uses only out
6Assembly1. Install the hopper latch as shown at left.2. Install 3 rebricks on the cast iron angle behind the grate as shown.3. Cement in grates as s
74 GLASS RE-TAINER CLIPS4 GLASS RETAINER BOLTSGLASSGLASS GASKETDOORHINGE PINSBRASS HANDLEHANDLE BOLTWOOD HANDLEPAW BOLTSET SCREWViewing glass
8Tips On InstallationBefore the positioning of the unit can be de-cided a few questions should be considered?1. Can the unit be vented properly and in
97. Check the exterior of the termination for best t and screw to exterior and caulk with high grade exterior caulking.8. Complete any other exterior
Comments to this Manuals